環氧地坪漆質量問題，80%以上都是施工技術上出現問題，因此，在進行無錫環氧地坪漆施工時一定要嚴格把好關，每一道涂層都要注重質量，只有把好質量關，才能做出優質的無錫防靜電地坪工程。環氧地坪漆施工工藝說難很難、說簡單也很簡單，只要掌握好五個要點，就能保證環氧地坪漆的施工質量，做出讓客戶滿意的環氧地坪漆工程。下面就給大家介紹環氧地坪漆施工過程中的五個要點：

More than 80% of the quality problems of epoxy floor paint are in construction technology. Therefore, we must strictly control the construction of epoxy floor paint. Every coating should pay attention to quality. Only if the quality of epoxy floor paint is well controlled, can we make high-quality epoxy floor project. The construction technology of epoxy floor paint is difficult, simple and simple. As long as five points are mastered well, the construction quality of epoxy floor paint can be guaranteed and the project of epoxy floor paint satisfying customers can be made. Here are five key points in the construction of epoxy floor paint. 

1、基礎地面處理：做好基礎地面的處理工作是做出優質環氧地坪漆工程的前提，環氧環氧地坪漆施工要求基礎地面強度要求不低于C25，地面平整度一般要求在2m范圍內落差不大于2mm，如地下水位較高則混凝土底層應作好防水處理，含水率不高于8%，沒有油污等雜物。處理完畢后，檢查基底的質量，避免質量效果不佳，而導致環氧地坪漆涂裝效果不佳。

1. Foundation ground treatment: good treatment of foundation ground is the precondition of making high-quality epoxy floor paint project. The construction of epoxy floor paint requires that the strength of foundation ground should not be lower than C25, and that the ground roughness should be less than 2m m in the range of 2m. If the groundwater level is high, the concrete bottom should be waterproof. Water content is not higher than 8%, no oil and other impurities. After treatment, the quality of the base is checked to avoid poor quality effect, which leads to poor coating effect of epoxy floor paint.

2、環氧地坪漆材料的質量：必須選擇正規地坪漆廠家生產的有質量保障的材料，所有進場材料都要進行檢查，杜絕不合格產品的使用。材料使用時必須按照使用說明嚴格按照配比進行調配，充分攪拌均勻。

2. Quality of Epoxy Floor Paint Material: Material with quality assurance produced by regular flooring paint manufacturers must be selected. All entrance materials should be inspected to prevent the use of substandard products. Material must be used in accordance with the instructions strictly in accordance with the proportion of mixing, fully mixing evenly.

3、施工工具的選擇：環氧地坪漆施工時所用的施工工具如：輥筒、刮刀、漆刷、美紋紙等必須選擇優質的產品，避免因地坪施工工具不良所導致的質量問題。

3. Selection of construction tools: The construction tools used in the construction of epoxy floor paint, such as roller, scraper, paint brush, paper and so on, must select high-quality products to avoid the quality problems caused by poor floor construction tools.

4、施工人員技術：要選擇經驗豐富的施工技術人員，無錫防靜電地坪施工人員應熟悉掌握本施工工藝的各項技術指標及施工方法，絕對不允許盲目施工、野蠻操作，特別是面漆施工時，一定要有三年以上工作經驗的。

4. Construction technicians: To select experienced construction technicians, construction personnel should be familiar with the technical indicators and construction methods of the construction technology, and absolutely not allow blind construction and barbaric operation, especially when finishing paint construction, must have more than three years of work experience.

5、無錫環氧地坪施工環境：無論封閉底漆、中涂漆、還是面漆，由于胺類固化劑反應一般低于5℃基本不反應，所以涂裝環境溫度在10℃以上時較佳，如低于這個溫度，對涂料則需采取一些改進措施。高濕度也對涂層外觀有很大影響，特別要避免在低溫高濕環境下施工，所以一般相對濕度小于85%時方能施工。

5. Construction environment: Whether closed primer, intermediate paint or topcoat, because the reaction of amine curing agent is generally lower than 5 C, it is better to apply the environment temperature above 10 C. If it is lower than this temperature, some improvement measures should be taken for the coatings. High humidity also has a great impact on the appearance of the coating, especially to avoid construction in low temperature and high humidity environment, so the general relative humidity is less than 85% before construction.